San Leon MUD Water Line Improvements Phase 4

The work in this contract is for Water Line Improvements Phase 4 for San Leon Municipal Utility District located in San Leon, Texas. The purpose of this project is to replace and upsize aging water lines in the San Leon Municipal Utility District, including gate valves and fire hydrants, to prevent future water main breaks and provide better service to the affected areas.

In general, this work consists of:

1. Installation of 2-inch, 6-inch, and 10-inch AWWA C-900 water line, by trenchless construction, for all depths, including tracer wire, restrained joints, bends, fittings, open left gate valves with boxes, and fire hydrant assemblies. Disinfection and hydrostatic testing shall be completed by the Contractor. Contractor shall install valve extensions for valves deeper than 5 feet.
2. Installation of minimum 12-inch and 18-inch steel casing, by trenchless construction, including fittings. Contractor shall ensure proposed water line with restrained joints and spacers has the needed clearance for installation inside the proposed steel casing.
3. Connection of the new water lines to the existing water system by tapping sleeve and valves and wet connections.
4. Line stop valves are to be used as directed by Engineer to minimize water service disruption in the event certain line segments prove difficult to isolate due to existing valve placement or existing valves being faulty.
5. Installation and connection of new long-side and short-side service leads, all diameters, from new water line to existing residential water meters or existing irrigation meters using tapping saddle with stainless steel band, including corporation valves and ball valve curb stops, with standard compression fittings at the meter connection. Service lines for all meters smaller than 1-inch shall be a single 1-inch service line with a standard compression fitting. Service lines for water meters 1-inch and larger shall be a single line that matches meter size for each meter. No 90-degree curb stops will be allowed. No U-Branches will be allowed. It will be the Contractor’s responsibility to ensure that all meters are reconnected to the new water line.
6. Abandonment of existing water lines, all sizes, all depths, including cutting, draining, plugging, and grouting the existing water line as shown in the plans.
7. Relocating and connecting existing fire hydrant assemblies and plugging the old fire hydrant connection on the existing line.
8. Site restoration of disturbed areas includes replacing damaged sidewalks, ramps, driveways, pavement, turf, plants, shrubs, trees, irrigation lines, fences, and gates.
9. Implementation, maintenance, and removal of traffic control plan, trench safety, and storm water pollution prevention plan best practices including inlet protection barriers.

 

## Details **Bid/Project ID:** 24170-125-10080-000 **Type of Work:** Water Line Installation **Pre-Bid Location:** 443 24th St., San Leon, Texas 77539 **Pre-Bid Notes:** A mandatory pre-bid conference for prospective bidders will be held at the office of San Leon Municipal Utility District, 443 24th St., San Leon, Texas 77539, on June 9, 2026, at 10:00 a.m. Bidders may also join online by teleconference: Dial #1-402-541-7284, enter access code 460 891 20#. Bidders may also join with the following link: https://teams.microsoft.com/meet/247957313781337?p=nZkAhPELU7ZsPsJjyL **Bid Location:** 443 24th St., San Leon, Texas 77539 **Bid Notes:** Sealed bids will be received either (i) electronically using the CIVCAST website, www.civcastusa.com, or (ii) by paper copy in duplicate, addressed to San Leon Municipal Utility District will be received at the office of San Leon Municipal Utility District, 443 24th St., San Leon, Texas 77539, until 10 a.m. , June 16, 2026, and then publicly opened and read for furnishing all labor, material and equipment and performing all work required for the construction of the following work: Project Name: Water Line Phase 4 Improvements San Leon Municipal Utility District; Galveston County, Texas; Project No. 125-10080-000 Bidders who want to attend the bid opening may do so in person at the address above or by teleconference. To join the teleconference, dial #1-402-541-7284, enter access code 314 307 508 #; Bidders may also join with the following link: https://teams.microsoft.com/meet/264239070580054?p=JiCsztalLLfOXmLHTA **Engineer/Publisher:** Lockwood, Andrews & Newnam, Inc. **Engineer Address:** 3700 West Sam Houston Parkway South, Suite 400, Houston, Texas, 77042 ## Additional Notes It is the responsibility of the contractor bidding the project to ensure the accuracy of the reproduction of all bid documents and construction drawings. This responsibility includes, but is not limited to, proper scaling, paper width and length, etc. Failure to do so may result in errors in the unit bid quantities and/or bid amounts.